Hyundai Creta: General Information / Troubleshooting
| Troubleshooting |
|
Symptom |
Suspected Area |
Remedy |
|
Clutch grabs/chatters |
Engine mounting (Loose) |
Tighten the engine mounting. |
|
Clutch disc assembly (Excessive runout) |
Inspect the clutch disc. |
|
|
Clutch disc assembly (Oily) |
Inspect the clutch disc. |
|
|
Clutch disc assembly (Worn out) |
Replace the clutch disc. |
|
|
Clutch disc torsion spring (Damaged) |
Replace the clutch disc. |
|
|
Clutch disc assembly (Glazed) |
Inspect the clutch disc. |
|
|
Diaphragm spring (Out of alignment) |
Replace the clutch disc. |
|
|
Clutch pedal spongy |
Clutch line (Air in line) |
Perform the air bleeding. |
|
Master cylinder (Damaged) |
Replace the master cylinder. |
|
|
Release cylinder (Damaged) |
Replace the release cylinder. |
|
|
Clutch noisy |
Clutch release bearing assembly (Worn, dirty or damaged) |
Repair or replace to release bearing. |
|
Clutch slips |
Clutch disc assembly (Oily) |
Inspect the clutch disc. |
|
Clutch disc assembly (Worn out) |
Replace the clutch disc. |
|
|
Diaphragm spring (Damaged) |
Replace the clutch disc. |
|
|
Pressure plate (Distorted) |
Replace the clutch disc. |
|
|
Flywheel (Distorted) |
Replace the flywheel. |
|
|
Clutch does not disengage |
Clutch line (Air in line) |
Perform the air bleeding. |
|
Master cylinder (Damaged) |
Replace the master cylinder. |
|
|
Release cylinder (Damaged) |
Replace the release cylinder. |
|
|
Clutch disc assembly (Out of line) |
Replace the clutch disc. |
|
|
Clutch disc assembly (Excessive runout) |
Replace the clutch disc. |
|
|
Clutch disc assembly (Lining broken) |
Replace the clutch disc. |
|
|
Clutch disc assembly (Dirty or burned) |
Repair or replace to release bearing. |
|
|
Clutch disc assembly (Oily) |
Inspect the clutch disc. |
|
|
Clutch disc assembly (Lack of spline grease) |
Apply the grease to spline. |
Special service tools
Special Service Tools
Tool (Number and name)
Illustration
Use
09411-1P000
Clutch disc guide
Install ...
Clutch System
...
Other information:
Hyundai Creta GS 2014-2019 Owners Manual: Normal maintenance schedule (Except Mexico) - Diesel engine
I : Inspect and if necessary, adjust, correct, clean or replace.
R : Replace or change.
*1 : Inspect drive belt tensioner, idler and alternator pulley and if necessary
correct or replace.
*2 : Check the engine oil level and leak every 500 km (350 miles) or before
starting a long trip.
...
Hyundai Creta GS 2014-2019 Service Manual: Accelerator Pedal: Repair procedures
Removal
1.
Turn the ignition switch OFF and disconnect the negative (-) battery
terminal.
2.
Disconnect the accelerator position sensor connector (A).
3.
Remove the mounting nuts (B).
...
