Hyundai Creta: Fuel Delivery System / Fuel Filter: Repair procedures

Hyundai Creta GS 2014-2025 Service Manual / Engine Control / Fuel System / Fuel Delivery System / Fuel Filter: Repair procedures

Removal

1.	Remove the fuel pump. (Refer to Fuel Delivery system - "Fuel Pump")

2.	Disconnect the electric pump wiring connector (A) and the fuel sender connector (B).

3.	Remove the fixing clip (A), and then separate the head assembly (B).

4.	Remove the reservoir-cup (B) after releasing the fixing hooks (A).

5.	Disconnect the electric motor pump connector (A) and the ground cable (B).

6.	Remove the cap (A), and then fuel pressure regulator (B).

7.	Remove the pre-filter (A) after releasing the hook.

8.	Separate the electric pump motor (A).

9.	Remove the fixing clip (A), and then assist pump assembly (B).

10.	Replace new fuel filter.

Installation

1.	Install in the reverse order of removal.

Fuel Pump: Repair procedures

Inspection [Fuel pump] 1. Turn ignition switch OFF and disconnect the negative (-) battery terminal. 2. Remove the fuel p ...

Fuel Pump Motor: Repair procedures

Removal 1. Remove the fuel pump. (Refer to Fuel Delivery System - "Fuel Pump") 2. Disconnect the electric pump wiring con ...

Other information:

Hyundai Creta GS 2014-2025 Service Manual: Troubleshooting
Troubleshooting Symptom Possible cause Remedy Hard steering Improper front wheel alignment Excessive turning resistance of lower arm ball joint Low tire pressure No power assist Correct Replace ...

Hyundai Creta GS 2014-2025 Service Manual: Special service tools
Special Service Tools Tool(Number and Name) Illustration Use 09568-1S100 Ball joint remover Ball joint remover 09495-3K000 Band installer Installation o ...