Hyundai Creta: Heater / Evaporator Core: Repair procedures

Replacement
1.
Disconnect the negative (-) battery terminal.
2.
Remove the heater and blower assembly.
(Refer to Heater -"Heater Unit")
3.
Remove the heater unit lower case (A) after loosening the mounting screws.

4.
Pull out the evaporator core (A) from the heater unit.

5.
Install in the reverse order of removal.
If you're installing a new heater core, add refrigerant oil (PAG OIL).
Replace the O-rings with new ones at each fitting, and apply a thin coat of refrigerant oil before installing them. Be sure to use the right O-rings for R-134a to avoid leakage.
Immediately after using the oil, replace the cap on the container, and seal it to avoid moisture absorption.
Do not spill the refrigerant oil on the vehicle; it may damage the paint; if the refrigerant oil contacts the paint, wash it off immediately.
Apply sealant to the grommets.
Make sure that there is no air leakage.
Charge the system and test its performance.
Do not interchange the inlet and outlet heater hoses and install the hose clamps securely.
Heater Core: Repair procedures
Replacement 1. Disconnect the negative (-) battery terminal. 2. Remove the heater and blower assembly. (Refer to Heater -"Hea ...

Temperature Control Actuator
Components and components location Components Location 1. Temperature control actuator Description and operation Description The temperat ...

Other information:

Hyundai Creta GS 2014-2021 Owners Manual: Checking the washer fluid level
Check the fluid level in the washer fluid reservoir and add fluid if necessary. Plain water may be used if washer fluid is not available. However, use washer solvent with antifreeze characteristics in cold climates to prevent freezing. NOTICE Do not use engine coolant or antifreeze i ...

Hyundai Creta GS 2014-2021 Service Manual: Front Cross Member: Repair procedures
Removal 1. Remove the front wheel and tire (A). Tightening torque : 88.3 ~ 107.9 N.m (9.0 ~ 11.0 kgf.m, 65.1 ~ 79.6 lb-ft) 2. Separate the stabilizer link (B) from the front st ...

© 2017-2021 www.hcrmangs.com